Hydrotech PURA QCUF Quick Change Ultrafiltration Drinking Wa User Manual Page 1

Quick Change Ultrafiltration Drinking Water SystemInstallation, Operation & Service Instructions with Part ListModels: QCUFwww.pura.com

8Tubing ConnectorsThe PURA system features reliable and convenient push-to-connect tubing connectors. Tubing is easily connected and disconnected fro

9Figure 7The exact placement of the components will vary by installation. Although shown beneath a sink, it may be installed in a basement, crawl spa

10The following steps will enable you to install the system quickly and orderly. Some variation may be necessary depending on the installation. See pa

11Step 2 – Faucet InstallationTo simplify its access and installation, we suggest you install the faucet on the rear lip of the sink. It should be eve

12FaucetBase(Remove white protective film)Plastic WasherLarge Rubber WasherSmall Rubber WasherNutFaucet AdapterLock Washer13567824Standard Fau

13Step 3 – Install Adapter Valve on Water SupplyCAUTION! If no shut off valve is installed under sink, close main water valve. Do not install feed wa

14Step 4 – Install Filter System AssemblyThe mounting bracket contains four mounting slots. The holes are sized to accept #10 round head wood screws

154Step 5 – Start-Up 1. Check system to verify all components are correctly installed 2. Open inlet valve and tank valve. 3. Check system thorough

16Service ScheduleTo keep the PURA system operating properly, it is necessary to change the filters and sanitize the system periodically. Typically, t

17Parts Breakdown# Item # Description Qty.1 134040U Manifold, Quick Change Ultrafilter, 4 Stage 12 41407001 Cartridge, Quick Change Sediment Filter -

18891075111213141624Other Parts 1. Faucet & Hardware – Part # 92192 2. Piercing Valve - Part # 92276 3. Locking Clip (3/8") –

19If a problem cannot be corrected through the use of this troubleshooting guide please have the following information ready prior to calling the 1-80

20PURA GuaranteeSubject to the conditions and limitations described below, WaterGroup warrants its PURA Ultrafiltration Drinking Water Treatment Syste

21

WaterGroup Companies, Inc.580 Park StreetRegina, SK, S4N 5A9, CanadaUSA Office:193 Osborne RoadFridley, MN, 55432, USAwww.pura.com55026.1212

1Safe PracticesThroughout this manual there are paragraphs set off by special headings.NOTE: Note is used to emphasize installation, operation or mai

2Table of Contents PageSpecifications and Performance Data Sheet ... 3Suggested Install

3Specifications and Performance Data SheetModel # Part # Stage 1 Stage 2 Stage 3 Stage 4 FaucetQCUF 1340201-60 Sediment Filter Sediment FilterUltrafil

4NOTES1. A softener is strongly recommended for water over 10 gpg hard. Installing a system without a softener on water with hardness higher than 10

5Suggested Installation Equipment Recommended Tools 1. Utility Knife 2. Flathead Screwdriver 3. Phillips Screwdriver 4. Center Punch 5. 7/8

6Overview of the PURA Quick Change UF System’s Components Manifold Assembly The manifold assembly serves as the functional hub of the PURA system by d

7 1. UF Manifold 2. Sediment Filter 3. Sediment Filter 4. Ultrafilter Membrane 5. Carbon Block Filter 6. Faucet and Hardware 7. Piercing